The Giammalvo 157 Point Quality Assurance Inspection requires 157
tests to ensure that interior and exterior mechanical and electronic components
perform as designed. Our ASE
certified technicians recondition each vehicle to our exacting standards.
Air Conditioning/Heating Systems
A/C cooling operation at specification
A/C sight glass clear
Inspect A/C and heating fan operation
Heater and defroster work properly
Dual Zone heater controls work correctly
Outside temperature sensor works correctly
Remote steering wheel climate control systems buttons work correctly
Brake System
Inspect brakes & measure pad/shoe thickness & replace if needed
Inspect for brake fluid leaks
Parking brake sets and holds vehicle
ABS operates on "panic stop"
Brake fluid clear and uncontaminated
Brake fluid at full mark
Brake pedal free play and travel per specification
Disc brake pad minimum: 5mm
Drum brake shoe-lining thickness minimum: 2.5 mm
No excessive grooving or heat checking of rotors or drums
No excessive pedal or chassis vibration on light and heavy braking
Parking brake releases completely
Traction control system works correctly
Chassis
Inspect frame
Inspect under body for corrosion
Cooling & Fuel System
Inspect for fuel leaks
Inspect for coolant leaks
Coolant specific gravity to minus 34 degrees Fahrenheit
Coolant boil-over protection to 320 degrees Fahrenheit
Engine coolant level at specification with cold engine
Inspect water pump shaft for play and leaks
Drive Axle
Differential fluid level correct
No ripped CV joint boots
Engine
Change engine oil and filter
Cold engine operation normal
Cold high idle correct
Drive belt tension at specification
Drive belts and hoses free of cracks or damage
Driveability OK during warm-up
Engine reaches normal operating temperature
Hot driveability normal
Inspect exhaust systems and hangers for leaks or damage
Inspect for oil leaks
Inspect for coolant & washer bottle leaks
No abnormal engine noise at cold start
No excessive drone or vibration from engine or driveline
Perform vehicle emissions testing as required by Massachusetts state
laws
Throttle does not stick shut
Electronic System
Air Bag Control Module clear of any fault codes
Anti-Lock Brake Control Module clear of any fault codes
Battery cables clean and serviceable
Battery mount secure
All wiper speeds work correctly
Convertible top operation function normally
Cruise control operation normal
Engine Control Module clear of any fault codes
Intermittent wipers work correctly
Memory Profile System works correctly
Power Train Control Module clear of any fault codes
Power windows operate from master switch and all door switches
Rear defogger grid lines intact
Rear defogger indicator light turns on with switch ON
Remote steering wheel audio control buttons work correctly
Sunroof closure warning system operates
Sunroof or convertible top operation normal through full range of positions
Transmission Control Module clear of any fault codes
Windshield washer operates
Wipers return to correct park position when turned off
Exterior
Backup lights working with no cracked or broken lenses
Brake lights working with no cracked or broken lenses
Bulbs are not cracked and have no water behind lens
Check for glass chips & cracks
Gas filler door remote release operates normally
Headlight alignment is normal
High and low beams of headlamps work correctly
License plate lights working with no cracked or broken lenses
Mirrors have full range of adjustment
Mirrors free from cracks
No excessive wind noise
Outside rearview mirror power or manual operation OK
Remove non-factory accessories that could compromise vehicle integrity
Slide marker lights working with no cracked or broken lenses
Taillights working with no cracked or broken lenses
Wheel covers, caps secure with no cracks or broken mount tabs
Interior
Ashtray clean and operates normally
Audio/cassette/CD system working normally
Automatic High Beam Dimmer functions normally
Cigarette lighter operates normally
Clock works and keeps time with key off
Cup holder extends out completely and provides adequate support
Dash light dimmer working
Day-night mirror operates OK
Dome/courtesy lights work, including operation for each door-opening
cycle
Door locks operate, including child safety locks
Doors open and close correctly
Driver's door window lock functions properly
Electronic Instrument Cluster operates properly
Factory alarm system works properly
Remove non-factory alarms that could compromise vehicle integrity
Fuel gauge reads correctly
Headlamp on warning works correctly
Heater lights working
Hood latch works
Horn(s) work
Illuminated vanity mirrors work normally
Instrument cluster lights working
Interior free of significant squeaks and rattles
Interior free of water leaks
Left turn signals operate and self-cancel with steering wheel operation
function
Low fuel warning works correctly
Memory seating positions work correctly
Power antenna mast extends and retracts fully
Power antenna motor works
Radio anti-theft system working normally
Radio speakers do not rattle at high-volume settings
Reading lamps work operate
Rear folding seats work correctly
Retained Accessory Power Relay works normally
Right turn signals operate and self-cancel with steering wheel operation
function
Seat belt indicator tab is intact with no tears or broken stitching
Seat belts have full range of extension and smooth operation
Seat belts lock up per specification
Seats operate normally, including recline, lumbar and cushion adjustments
Twilight Sentinel works normally
Warning lights ON with key ON, engine OFF
Weatherstrips not torn or damaged
Windows operate normally
Luggage Compartment
Inside trunk release operates normally
Jack and tools are correct and secured
No water leaks in trunk
Spare tire in safe condition
Spare tire pressure correct
Trunk latch works
Trunk light works properly
Trunk trim appearance normal
Steering
No excessive tire vibration or steering wheel shimmy at any speed
Power steering fluid level at full mark
Steering operation has normal feel
Steering wheel centered in straight-line driving
Tilt steering wheel operates correctly
Telescopic steering column works correctly
Vehicle tracks and drives straight on level surface
Variable assist steering works correctly
Suspension
Alignment settings, (caster, camber, & toe) all within specification
Auto Leveling Suspension functions normally
Minimum 6/32" tire tread remaining (more than MA state requirement
of 2/32)
Tires on the ground are same brand, size and load rating
No tire damage, bulges or cupping
No missing valve stem caps
Shock absorbers exhibit no excessive wear or leakage
Struts exhibit no excessive wear or leakage
Tire pressures set to specification
Tires balanced including full size spare
Transmission
Auto transmission park position and shift lock function properly
Clutch fluid level at full mark
Clutch operates smoothly with no abnormal noise or vibration
Transfer case switches from 2WD to 4WD upon demand and 4WD to 2WD smoothly
Transmission and transfer case fluids are clear and free of dirt
Transmission and transfer case fluids are correct
Transmission does not shift into overdrive when button is in OFF position
Transmission operates smoothly with no abnormal noise or vibration
|